Framing Day

Old living room with no walls

Another angle of the first floor, pre-framing

Hello, new walls

Mudroom to the right, den/bedroom to the left

Interior of the mudroom with two closets framed out

We've been working away on framing up the first floor and are nearly finished now.  We've built the new mudroom and den/bedroom and framed up the closets in the mudroom as well.  So we've gone from too many walls and very small rooms to no walls and no rooms to just the right mix (we hope) of functional and right-sized rooms.  Next up, rerouting the HVAC vents, running electric, and some more demo of the old bathroom and plumbing for the new one.  It might not be much to look at now, but we're making progress.

Another Day, Another Wall Down

We continued our holiday celebration today by taking down another wall!  Today's project was the wall between the living room and kitchen and it turned out to take much longer than we expected.  Perhaps we got spoiled yesterday when everything went so smoothly.  We had to demo the existing wall, build the temporary walls, demo the old wall, and then install the beam.  The first three steps went smoothly but then we realized that a couple of vents ran under where we intended to put the supporting 2 x 4s so we had to move the vents and install solid blocking in order to have sufficient structural support.  That took longer than expected but we got it done.  This was the third and final beam so it's another item to check off our list! 

Merry Christmas, Part II

Merry Christmas from the construction zone!  We celebrated in our favorite way - by building and tearing down walls!  We've been putting our wood pile to good use, building a number of temporary walls so we could install the beams and, ultimately, take down the temporary and formerly permanent walls.  We've made a huge amount of progress and have two of the three beams installed so we're very close to having the first floor completely opened up.  We're installing Parallam beams and will leave them exposed to provide architectural interest.  We'll probably stain them a slightly darker color than they currently are but we'll wait until the new walls are up to make that decision.  Right now, it's just nice to see all the open space and say goodbye to the tiny old rooms.  We also owe a big thanks to my friend Jessica, who agreed to come visit us and help out despite the very long disclaimer email I sent in advance warning her about the state of our house and our "festive" plans for hard labor.  We're looking forward to more work, and more progress, over the next few days!

Merry Christmas

Our Christmas present arrived early this year. This giant pile of lumber will become our new walls soon. I don't think it will fit under the Christmas tree... If we had one that is. Tomorrow we will clean out the basement and hopefully start framing. Should be a nice project over the holiday break.

One Wall Down

As expected, we spent most of the weekend cleaning up after the demo and I have a feeling the "clean up" will continue every day for the next few months as we attempt to control the dust level in the house.  It's just the price of living in a construction zone! We also pulled all the old electrical wire, removed most of the nails from the old beams, and took down one of the old walls to start opening up the living room.  We're knocking out the nails and saving the old 2 x 4s as they're really nice old wood.  At some point in the future (namely, after we have a functioning first floor again), we'll use the old wood to build furniture or for other projects.

We also spent a good bit of the day planning the layout and making sure that we are happy with the floor plans.  If there's one thing we've learned throughout this renovation, it's that we have a tendency to make small but noticeable changes once we start laying things out in real life as opposed to just looking at the plans on paper.  The old part of the first floor will change from housing a living room, dining room, galley kitchen, two small bedrooms and a full bathroom to a living room, mud room, den/guest bedroom/office with full bath, half bath, and pantry.  In short, nothing will be left untouched and we'll be opening up a good bit of the existing support walls as well.  The load bearing walls run horizontally across the width of the house so we'll leave those walls up until the beams arrive. As it is, we'll have to build a couple of temporary walls before we can install the beams but there's no need to build extras when we can use the old walls instead.  The next few weekends will probably be a fair amount of work as we get the first floor and basement ready for framing.  We're back in the prep phase but making progress!

The Day After

A few more pictures now that the dust has settled - and it has settled everywhere!  The cats have turned into living dust bunnies as they run around the house and it's probably only a matter of time until one of them falls through the now non-existent floor of the old bathroom.  At least they'll land in the basement if that happens!  We'll spend the next couple of days cleaning up and planning out the exact details of reconstruction.  I foresee a lot of vacuuming and dusting in the future!

Demo Day

It was a longer day then I expected, but most of the demo is done. We got about 95% done and all that's left is some cleanup and miscellaneous stuff like electrical. I'm sore, tired, and beat up. So glad we hired out some help for this. It would have been more than Kristin and I would have been able to handle in one weekend. There's an inch of dust everywhere, but it feels good to have phase 3 (or is it 4) underway!

Ready for Demo

It's back to living in a construction zone again!  After a few months of respite as we worked outdoors, our project is moving back inside and with it, all the dust, crowding, and chaos of living in a workspace.  In order to get ready, we spent the weekend clearing out the first floor and relocating everything either to the first floor addition (our makeshift living room is now right next to the kitchen - it's like living in a studio apartment...with dust) or upstairs to the second floor.  The kitties fall in the latter category and we moved their bedroom (because yes, they have their own bedroom) up to the second floor.  Mouse handled the relocation decently but Ollie spent most of the day hiding in a makeshift box, staring balefully at us, and I don't think he's going to be any more pleased when we start knocking down walls and ceilings this coming week.  In the meantime, we've got a bunch of "before" pictures to share now - check back on Thursday night or Friday for the "after" pictures.  Brian is taking a couple of days off work and has some helpers coming in so there's a good chance we'll be wall-free by Friday.  And then the real fun begins as we start putting it all back together again!

Finishing Touches

We're here!  We took some time off from house-building to travel up north and celebrate Thanksgiving with family and now that we're home, we've been wrapping up what I think of as Phase II of construction, e.g., the garage and backyard.  Brian has been running the electric and installing the final trim around the garage door and other various and sundry places and I think we can officially now call the garage complete with one caveat.  We had a hiccup with the garage door opener when the automatic stop malfunctioned on the first run and, sadly, warped the top panel of the garage door in the process.  Fortunately, the manufacturer, Genie, has so far been great about remedying the problem.  They sent a guy out to look at it, he confirmed that it was a problem with the unit (and not, happily, with the DIY installation!), and they're sending us a new unit and replacing the top panel of the door.  So we will have a little more work to do once those supplies arrive and, for now, we're manually opening and closing the door but with frosty nights now, we're very glad to have the cars housed indoors.

We've also been doing a fair bit of indoor work over the past two weeks, cleaning and organizing in preparation for Phase III - the demo and reconstruction of the first floor.  Even though we have paint patches all over the house and piles of trim and flooring underfoot, we've had a bit of a respite from living in a true construction zone these last few months as most of the work - and the mess - occurred outdoors.  But, those days are soon to be over.  It'll probably be another couple of weeks before we start taking the house apart but we're using the time to figure out a plan...and stealing ourselves to start living with the construction dust again!